Tighten the governor spring located in the engine of most golf carts to adjust your cart's top speed. 90% of EZ Go Carts have simple springs which limit the speed of the engine. To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly.
How do I increase the speed of my EZ Go golf cart?
One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.
How do you remove the speed limiter on a electric golf cart?
Basically, an electric speed governor can be controlled by a tiny metal rod that's located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.
How do you adjust the governor on a EZ Go TXT golf cart?
How to Adjust the Governor on a Gas E-Z-Go Golf Cart
- Locate the governor arm mounted on top of the rear axle case underneath the cart. ...
- Loosen the adjusting locknut on the end of the governor spring. ...
- Retighten the adjusting locknut.
How can I make my EZ Go TXT 36 volt faster?
How to Make a 36 Volt Golf Cart Faster
- Remove any unnecessary additions, racks or parts on your golf cart. ...
- Power-wash your cart. ...
- Check the shaft under the ignition pedal. ...
- Put larger tires on the cart. ...
- Replace any old or worn-out parts that are causing the cart to move slower than it should.
Why is my gas golf cart running slow?
Low Battery
Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
Where is the limiter on a golf cart?
Locate the golf cart's governor; you can find the governor by tracing the thickest cable running from the gas pedal. This cable runs through the governor on its way to the carburetor. Use a screwdriver—or in some cases a wrench—to loosen the tension on the governor's springs.
Is 30 mph fast for a golf cart?
Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.
How do you take the governor off a electric Club Car golf cart?
Look behind the governor to find a small metal rod that's permanently attached to the club car and stretch your rubber band enough to connect it to that metal rod. Screw the plastic plate back in place. Once the plate is back in place, the governor is disabled.
How fast is a EZ Go golf cart?
The fastest gasoline Club Car only goes 19 mph. And the fastest electric EZGO is the 2Five that goes 25 mph. And the fastest EZGO gasoline golf cart also only goes 19 mph.
How do I tell what model my EZ Go golf cart is?
The serial number and manufacturer's number for these EZGO golf cart models can be found on a plate located under the glove box on the passenger's side of the vehicle. The serial number is either six or seven numbers and does not indicate the model year. The manufacturer's number does reflect the model year.
How fast can a 36 volt golf cart go?
How fast is a 36 volt golf cart? Without any upgrades, you can plan on max speeds between 12-14 mph.
Will bigger tires make my golf cart faster?
The larger surface area of the bigger tires and wheels increases the maximum possible miles per hour. In some cases, this can be a boost of 300%! The bigger the tires, the better the speed.
How do you adjust the carburetor on a EZ Go golf cart?
2 Cycle engine: The adjustment screw is on the side of the carburetor and is parallel to the ground. You can identify it by the lock nut at the base of the screw. Loosen this and turn the screw all the way into a soft seat, then back it out one and a half (1-1/2) turns.
How fast do most golf carts go?
What is the Average Golf Cart Speed? The average top speed of a typical golf cart without any upgrades is between 12 and 14 miles per hour. Without any sort of modification or upgrade on a golf cart, the top speed that you will be getting on a golf cart is about 14mph.
How much air pressure do you put in golf cart tires?
These tires typically use anywhere from 15 to 25 pounds per square inch (PSI), with the average being 20 to 22 PSI. For golf carts driven off-road or on rougher terrain, it's not uncommon to under-inflate tires to gain additional traction. However, under-inflated tires wear down prematurely.
How fast can a golf cart go without a governor?
Consider Replacing Your Speed Control
A typical electric cart without an upgraded speed control tops out around 12 mph. If you go this route, anticipate an upgrade cost around $700.
How does a golf cart governor work?
By mechanically pulling the throttle lever back, you decrease the gas flow to the engine and control the golf cart's speed. This governor can be adjusted by adjusting the cable nut which holds the cable to the throttle lever.
How do you make a gas golf cart faster?
6 Ways You Can Make a Golf Cart Faster
- Add More Torque to Your Golf Cart.
- Upgrade Your Golf Cart's Motor.
- Improve the High-Speed Controller of the Cart.
- Add Better Golf Cart Tires.
- Use a Higher Powered Golf Cart Battery.
- Watch the Weight in Your Golf Cart.
How can I make my gas Club Car golf cart go faster?
Increase the RPM
An increase in the input shaft rpm for all differential ratios will produce a higher speed. For a gas golf cart, other than adjusting the governor, the speed may be enhanced by replacing the engine with a higher rpm output model.
How do I test my EZ GO speed sensor?
Testing a Golf Cart Speed Sensor
- Activate the Row/Tow switch. To do this, you must put the golf cart in the “run” position while pushing the cart itself. ...
- Make sure the three-pin plug is connected to the sensor. To ensure it is connected, with the output of the green wire, place the piercing probe.
How can I add more torque to my golf cart?
Change the Speed ControllerThe Speed Controller regulates the electric output of the motor; a higher voltage equals more RPM, and the faster your cart will travel. When you change the speed controller, you can reduce the voltage and increase the amperage of the motor, resulting in increased torque.
